This investigation focused on the use of asphalt shingles that had been removed from roofs and recycled into asphalt concrete. Upon invitation by the Virginia Department of Transportation (VDOT), three asphalt contractors produced and placed sections of asphalt concrete containing shingles. The sections were sampled and tested by the Virginia Transportation Research Council. Two base mixes and two surface mixes were produced, and one of the surface mixes was produced by both hot mix and warm mix technology. The laboratory tests used to evaluate the mixes were tests to determine conventional gyratory volumetric properties, gradation, and asphalt content; rut tests; fatigue tests; and tests to determine recovered asphalt properties. Satisfactory test results and good paving experiences with regard to the field installations indicated that mixes containing tear-off shingles can be constructed successfully. According to cost estimates, in 2009, VDOT could have saved approximately $600,000 by using 4 to 5 percent shingle waste in one-half of the hot mix produced. VDOT plans to adopt the special provision used for this study with minor modifications as a general specification for paving in 2010.
The Virginia Department of Transportation (VDOT) is faced with trying to maintain its roads with materials whose cost is increasing at an alarming rat...
This tech brief presents information about intelligent compaction (IC) technology and helps to promote its use throughout the United States. A compani...
Links with this icon indicate that you are leaving a Bureau of Transportation
Statistics (BTS)/National Transportation Library (NTL)
Web-based service.
Thank you for visiting.
You are about to access a non-government link outside of
the U.S. Department of Transportation's National
Transportation Library.
Please note: While links to Web sites outside of DOT are
offered for your convenience, when you exit DOT Web sites,
Federal privacy policy and Section 508 of the Rehabilitation
Act (accessibility requirements) no longer apply. In
addition, DOT does not attest to the accuracy, relevance,
timeliness or completeness of information provided by linked
sites. Linking to a Web site does not constitute an
endorsement by DOT of the sponsors of the site or the
products presented on the site. For more information, please
view DOT's Web site linking policy.
To get back to the page you were previously viewing, click
your Cancel button.
United States Department of Transportation
[PDF-228.27 KB]
